介紹环氧地坪漆在陰雨天如何施工?方法?

文章时间:2018-10-13 21:12   浏览次数:

有些消費者認為环氧地坪施工僅需考慮基面情況和环氧地坪材料以及施工技術。但环氧地坪是高質量高要求的產品,它不僅要求施工專業,塗料本身對塗裝环境條件有需要,隻需在契合該需要的环境下施工,才會達到最佳的效果。陰雨天氣由於空氣濕度較大、地面幹燥不充分,而且环氧地坪由於其特殊的成份不能像水泥混凝土那樣能和水很好的融合。所以,在我們感覺地面水份含量不大的情況下其往往還達不到施工條件,环氧樹脂地板這樣一來盲目施工便會造成之後的地面脫層、氣泡能問題。
Some consumers think that floor construction only needs to consider the base level and floor material and construction technology. But the epoxy floor is a product with high quality and high requirement. It requires not only the construction specialty, but also the coating environment. The best effect can be achieved only when the epoxy floor is constructed in the suitable environment. Rainy weather due to the humidity of the air, the ground is not dry enough, and epoxy floor because of its special composition can not be as good as cement concrete and water fusion. Therefore, when we feel that the ground moisture content is not very high, it often can not reach the construction conditions, epoxy flooring blindly construction will cause delamination of the ground after, bubble energy problems.
如果因為陰雨天氣地面無法正常幹燥,可以使用機械烘幹。环氧地坪漆最適宜的施工天氣是有適當風力,氣溫在20°左右。环氧地坪需要施工2~3道工序,环氧樹脂地坪漆我們必須保證每一道工序材料都完全幹燥才能進行下一步工序。
If the ground can not dry normally in rainy weather, mechanical drying can be used. The most suitable construction weather for epoxy floor paint is proper wind force and the temperature is about 20 degrees. Epoxy floor requires two to three processes. Epoxy floor paint must be completely dry in each proces彩色沥清地坪s before the next process can be carried out.
下雨天氣,氣壓普偏低,這時候施工环氧地坪濃就容易殘留很多有窖物質,且這些物質不易揮發。所以建議將施工場地的門窗打開,做好室內通風工作,這樣不僅可以加以快室內空氣的流動性,也能保障施工人員的身體健康。下雨天氣施工环氧地坪漆,做好周圍的防護措施,底層施工需要準備工業專用的除濕器。
Rainy weather, low air pressure, this time the construction of epoxy floor is easy to leave a lot of cellar material, and these materials are not volatile. Therefore, it is suggested to open the doors and windows of the construction site and do a good job of indoor ventilation, which can not only speed up the fluidity of indoor air, but also protect the health of the construction personnel. In rainy weather, epoxy floor paint should be used, and protective measures should be taken. Dehumidifiers for industrial use should be prepared for bottom construction.
如果空氣比較潮濕,地面也會受到影響,如果在這樣潮濕的地面直接施工环氧地平漆,容易造成地坪起翹,所以施工前一定要保證地面的幹燥,幹濕接壤的地方可以使用隔斷處理的方法。
If the air is humid, the ground will also be affected, if in such a humid ground direct application of epoxy floor paint, easy to cause the floor to warp, so before the construction must ensure that the ground is dry, wet and dry areas can use the method of partition treatment.
雨天施工,环氧地坪漆容易發白。這種天氣,墻面和地面都會存在水汽,上材料也不容易幹燥,如果膩子還沒有幹透就進行下一步施工就會出現一系列塗膜弊病甚至開裂。所以要保證每一道工序材料完全幹燥之後再進行下一層。或者在材料中加入適量的白化水調和劑也可以加速塗料的幹燥。
On rainy days, epoxy floor paint is whitish. In this weather, there will be water vapor on the wall and the ground, the material is not easy to dry, if the putty has not dried through the next step of construction will appear a series of film defects and even 印花地坪cracks. Therefore, we must ensure that every process material is completely dry before proceeding to the next level. Or adding proper amount of albino water to the material can also accelerate the drying of the paint.
空氣中的含水率即濕度,可以用濕度計測量,一般环氧地坪漆施工時最好濕度在85%以下。陰雨天濕度大,容易影響塗層的固化,同時水霧在环氧土也坪表面易產生發白現象,從而影響其使用效果。
Moisture content in the air, that is, humidity, can be measured with a hygrometer, general epoxy floor paint construction, the best humidity is below 85%. High humidity in cloudy and rainy days can easily affect the solidification of the coatings, and the water mist on the surface of epoxy soil can easily produce whitening phenomenon, thus affecting its application effect.
其次,陰雨天氣氣溫較低,雙組份环氧地坪由於要進行必要的配比才能使用,這樣一來很容易造成主劑和固化劑混合不充分的情況,從而降低地坪的施工質量。
Secondly, because of the low temperature in cloudy and rainy weather, the two-component epoxy floors can not be used until necessary mixing ratio is carried out, so it is easy to cause insufficient mixing of main agent and curing agent, thus reducing the construction quality of the floors.

相关推荐
环氧地坪选择涂料构架 水泥地面硬化剂 材料的功 艺术压模地坪施工 聚氨酯地坪涂料的施工注 环氧地坪漆涂膜质量检测 渗透剂厂家有哪些?让我 為什麼說环氧地坪施工环 為什麼环氧地坪漆施工需 环氧地坪漆薄塗常用素面 严格施工流程才能打造高